P 03 5873 2114
  • PACKAGES

    We ship direct to your address but first to choose the most suitable package..  

    A: Establish the capacity of the cabinet to be refrigerated. (Hcm x Wcm x Lcm divide by 1000  = litres. ie: a cabinet 50cm H x 50cm W x 70cm L would be 175Lts.)

    B: Check the chart on the ‘Cabinet Tips’ page. Locate the suggested package for your cabinet’s size, insulation thickness and operation. (Eutectic plate(s) can be ‘portrait or landscape’ orientation.)

    C: Next choose the condensing unit preferred. (Details on ‘Products’ page.

    D: Now refer to the following package examples as a starting point but discuss your project with us before ordering so pipe lengths etc., can be customised. Each package can be supplied with a second cold plate to suit larger fridge cabinets or freezers.

    Cyclic Package One.. THIS PACKAGE NO LONGER AVAILABLE

    AS450 Refrigeration unit with single Cyclic Plate: Au$1078.00 or  AS450 Refrigeration unit with twin Cyclic Plates:  Au$1239.00

    Air cooled 12 volt unit with twin fan condenser and BE50 compressor. Suits fridge cabinets to 150 litres and freezers to 120 litres with twin plates.

    *Rated at 40.30 AHs per day. 150 Lire cabinet. (1.68 Amps per hour ave)

     

     

     

     

     

     

    Eutectic Package One ..

    A480 Refrigeration Unit with a P33-29-5  Eutectic Plate.                 RRP Au$1684.40,  or

    ..
    AW480 Refrigeration Unit with a P33-29-5  Eutectic Plate..              RRP Au$1791.50.  

    This compact system package has our smallest eutectic plate and suits properly insulated refrigerator cabinets up to 90 litres, or properly insulated freezers up to 50 litres, with a single plate. Extremely low power consumption. Typically if installed in a 90 litre refrigerator it would consume approximately 8 to 12 amp/ hrs per day during cooler months and up to double that during summer. The new A480 is particularly suited to this and other smaller eutectic plates.

    The AW480 operates best with water cooling although not essential for single plate operation. The additional 1/4 amp consumed by the water pump is more than compensated by the much lower compressor consumption rate and run times. The water pump and fan are both thermostatically controlled to prevent over-condensing when in cooler environments. Water cooling is essential for all twin plate systems and if for tropical use.
    *Rated at 25.5 AHs per day. 150 Lire cabinet. (1.06 Amps per hour ave)(Air cooled model) 
    ..
    Eutectic Package Two

     

    A480 Refrigeration Unit with a P40-33-5 Eutectic Plate..            RRP Au$1710.50  or
    ..

    AW480 Refrigeration Unit with a P40-33-5 Eutectic Plate..            RRP Au$1817.60.

    This compact system package has our mid-sized eutectic plate and suits properly insulated refrigerator cabinets up to 150 litres, or properly insulated freezers up to 70 litres, with a single plate. The twin (thin) eutectic plate package suits larger properly insulated cabinets. Also see package selection chart at the ‘Cabinet Ideas’ page. Extremely low power consumption. Typically if installed in a 100 litre refrigerator it would consume approximately 10 to 13 amp/hrs per day during cooler months and up to double that during summer. .All AW480 models are equipped with the unique Ozefridge twin coil, air/water cooled condenser. This amazing condenser allows the unit to operate as an air cooled or water cooled system without the usual problems of electrolysis or fouling. The additional 1/3 of an amp consumed by the water pump is more than compensated by the much lower compressor consumption rate and run times. The water pump and fan are both thermostatically controlled to prevent over-condensing when in cooler environments. Water cooling is essential for all twin plate systems and tropical use.

    Click here to enquire now:

    *Rated at 24.6 AHs per day. 150 Lire cabinet. (1.02 Amps per hour ave. Air cooled model)

    Eutectic Package Three..

     

    A480  Refrigeration Unit with a P53-35-5  Eutectic Plate.                    RRP Au$1748.50 or

    AW480 Refrigeration Unit with a P53-35-5  Eutectic Plate.                 RRP Au$1855.70.

    ..

    This system package has a large capacity eutectic plate and suits properly insulated refrigerator cabinets up to 260* litres or freezers up to 110* litres. (*With a single plate in a properly insulated cabinet.. or up to 350 litre fridge with twin plates.) *Best with condenser water cooling. (Water cooling is essential for twin plate systems, or tropical for use) The thinner P53-35-4 plates are best when operating as a freezer. Extremely low power consumption. Typically a 200 litre refrigerator would consume approximately 15 to 21 amps per day during cooler months and up to double that during the summer. The controller is programmable with switches to allow the unit to be in: (A) Sleep Mode or Run Mode (B) Manual run or Auto run (C) Optional EC02 on or off. (D) Air only or Plus water. The ‘Manual’ switch allows the system to continue running if the control electronics fail or if extra cooling required when loading. An LED indicates default and advises likely cause such as low or high voltage, overload cut-off, overheat cut-off, faulty fan etc…

    Click here to enquire now..

    *Rating: 22.4 Amp Hours per day. 150 Lire cabinet. (0.89 Amps per hour ave. Air & water cooled model)

    This model with twin thin plates, is ideal for larger freezers or combination fridge/freezer cabinets. See sketch below

    Right:

    A fridge / freezer combination cabinet can be refrigerated using twin (thin) eutectic plates. These plates service the freezer while the adjacent fridge area is refrigerated via air cooled as it is forced through the stainless steel heat exchanger, by the thermo-fan unit.

    ……

     

    Each Ozefridge System Package includes:
    • 1 x AS450, A480 or AW480 12VDC refrigeration unit evacuated and gas charged.
    • 1 x Insulated pipe run to length etc. as nominated.
    • 1 x Digital controller panel front mounted or remote. (A480 & AW480 only)
    • 1 x Single or Twin cyclic or eutectic plate with *2.0 Metres of pipe run.
    • 1 x P3 Water pump with 10Mts of tubing and check valve. (AW480 only)
    • 1 x ECO2 Power Management system. (Built-in. A480 & AW480 only)
    • 1 x Miscellaneous install pack includes SS mounting screws, etc.
    • 1 x Installation and users Manual. (With local online/ phone back-up)
    • 1 x Secure packaging and delivery to your address with TNT (Overseas UPS)

    12 months plus parts warranty. (Minimum) 5 Years on compressor.

    IMPORTANT: As Ozefridge Industries Pty. Ltd. supplies refrigeration systems to be installed by others of whom we have no control over and into an existing or new cabinet that has insulation properties etc. we can not be assured of, we do not guarantee cabinet temperature outcomes in this or any other quotation or statement.

    WARRANTY: Ozefridge provides a minimum of 12 months warranty with 5 years on the compresor subject to the conditions described in the owners manual. This warranty is limited to the supply of replacement parts by post or a complete unit rebuild if the unit is returned to Ozefridge.  We do not reimburse costs incurred as a result of work carried out by others.

    CONSIDERATIONS

    Refrigeration systems operating under extreme conditions require specific engineering and build considerations to enable performance as expected. Typically they must withstand erratic power supplies of different voltages, rough movement, high ambient temperatures, corrosive environments, extreme angles etc., all whilst performing efficiently and quietly. Built-in fail-safe is essential, but battery power consumption is usually most important. Each application of marine refrigeration is somewhat unique, therefore we prefer to interact with our clients and address needs individually. Buying a refrigeration system off the shelf or without first addressing the relevant issues, will most likely end in tears!

    WHY OZEFRIDGE?

    Multi-voltage eutectic refrigeration is all we do and we do it very well.  At Ozefridge our manufacturing standards are based upon marine application where users demand best possible materials, build quality and performance. Service, support and warranty? …….Ask an Ozefridge owner.

    Buying direct we can customise your equipment and provide assistance that only a local maker can offer. Call for a quote.. +61 0358732114 or 0417864450 Everyday support.

    Call us on: +61 0358732114

    Or mobile: 0417864450

     

    ^ Back to Top ^

     

    Or click here to contact us now!

    // ]]><a